Please use this identifier to cite or link to this item: http://essuir.sumdu.edu.ua/handle/123456789/56824
Or use following links to share this resource in social networks: Recommend this item
Title Триботехнические и физико-механические свойства защитных покрытий из Ni-Cr-B-Si-Fe /WC-Co-Cr до и после оплавления плазменной струей
Other Titles Tribological and Physical–Mechanical Properties of Protective Coatings from Ni–Cr–B–Si–Fe/WC–Co–Cr before and after Fission with a Plasma Jet
Authors Bratushka, Serhii Mykolaiovych  
Pohrebniak, Oleksandr Dmytrovych  
Illiashenko, Maksym Viktorovych
ORCID http://orcid.org/0000-0003-3470-2265
http://orcid.org/0000-0002-9218-6492
Keywords физико-химические свойства
упругость
плазменные покрытия
plasma coatings
physical–chemical properties
wear rate
Type Article
Date of Issue 2011
URI http://essuir.sumdu.edu.ua/handle/123456789/56824
Publisher Институт механики металлополимерных систем им. В.А. Белого НАН Беларуси
License
Citation Погребняк, А.Д. Триботехнические и физико-механические свойства защитных покрытий из Ni-Cr-B-Si-Fe/WC-Co-Cr до и после оплавления плазменной струей [Текст] / А.Д. Погребняк, С.Н. Братушка, М. В. Ильяшенко и др. // Трение и знос. – 2011. – Т. 32. - № 2. - С. 122-130.
Abstract Разработан новый тип покрытия, состав которого представляет механическую смесь двух разных порошков таких составов: Ni-Cr-B-Si-Fe (ПГ-19Н-01) и WC-Co (твердый сплав). После нанесения покрытий из этой смеси полученный приповерхностный слой был оплавлен плазменной струей с эродирующим электродам из W. В результате дополнительной обработки покрытия плазменной струей было обнаружено формирование новых фаз и перераспределение элементов в слое глубиной 45-60 мкм, а также изменение процентного соотношения сформировавшихся при осаждении покрытия фаз: WC, -CoCr, Co, Ni, Cr3Ni2+-(Fe, Ni). Обнаружено перераспределение элементов в верхнем слое покрытия в результате плавления плазменной струей. В результате этих процессов происходит изменение физико-механических свойств (твердости, модуля упругости), скорость износа при трении цилиндра по поверхности образцов уменьшается в несколько раз. Было обнаружено, что с увеличением нагрузки на пирамидку Берковича модуль упругости Еср в покрытии уменьшается от Е = 240 ГПа (при глубине индентации 50 нм ) до Е = 175 ГПа (при 150 нм). При этом модуль упругости подложки из меди растет от 25 до 42 ГПа соответственно. Твердость покрытия, рассчитанная по кривым «нагрузка-разгрузка», составляет от 15,3 ГПа до 10,6 ГПа (при увеличении нагрузки на индентор). При трении цилиндра по поверхности покрытия наименьший унос материала обнаружен у образцов с покрытием, оплавленным плазменной струей в 3 прохода.
A new type of coating is developed, which is a mechanical mixture of two different powders, namely, Ni–Cr–B–Si–Fe (PG 19N 01) and WC–Co (hard alloy). After the coatings from this mixture are deposited, their surface layer is fused with a plasma jet using an eroding electrode made of W. The additional treatment of the coatings with the plasma jet yields new phases and causes the redistribution of elements in the layer 45– 60 μm deep; the percentage ratio of the phases WC, α CoCr, Co, and Ni, as well as Cr3Ni2 + γ (Fe, Ni) appear ing during coating deposition also changes. The redistribution of elements occurs in the upper coating layer owing to fusion with the plasma jet. These processes yield variations in the physical–mechanical properties of the coatings, such as the hardness and elastic modulus; the coating wear rate decreases severalfold. It is found that with increasing load applied to the Berkovich pyramid the elastic modulus of the coating drops from 240 (at an indentation depth of 50 nm) to 175 GPa (at 150 nm). The elastic modulus of the substrate rises from 25 to 42 GPa. The coating hardness calculated from the loading–unloading curves is 15.3 to 10.6 GPa under increased load applied to the indentor. Specimens covered with the coating fused with the plasma jet in three passes demonstrate the lowest material wear.
Appears in Collections: Наукові видання (ННІ БТ)

Views

Germany Germany
21
Ireland Ireland
63384
Italy Italy
1
Kazakhstan Kazakhstan
63382
Lithuania Lithuania
1
Netherlands Netherlands
1912
Russia Russia
1
Ukraine Ukraine
1047748
United Kingdom United Kingdom
459047
United States United States
5365572
Unknown Country Unknown Country
10

Downloads

China China
1
Germany Germany
2
Kazakhstan Kazakhstan
1
Romania Romania
22
Russia Russia
4
Ukraine Ukraine
2094557
United Kingdom United Kingdom
1
United States United States
5365573
Unknown Country Unknown Country
8

Files

File Size Format Downloads
Pohrebniak_Trybotekhnycheskye_fyzyko_mekhanycheskye_svoistva.pdf 1,7 MB Adobe PDF 7460169

Items in DSpace are protected by copyright, with all rights reserved, unless otherwise indicated.